點擊圖片查看大圖
Honeywell 10105/2/1 VVVF變頻、矢量控制變頻、直接轉矩控制變頻都是交-直-交變頻中的一種。其共同缺點是輸入功率因數低，諧波電流大，直流電路需要大的儲能電容，再生能量又不能反饋回電網，即不能進行四象限運行。為此，矩陣式交-交變頻應運而生。由于矩陣式交-交變頻省去了中間直流環節，從而省去了體積大、價格貴的電解電容。它能實現功率因數為l，輸入電流為正弦且能四象限運行，系統的功率密度大。該技術目前雖尚未成熟，但仍吸引著眾多的學者深入研究。其實質不是間接的控制電流、磁鏈等量，而是把轉矩直接作為被控制量來實現的。具體方法是：
廈門岳航計算機工程有限公司
聯系人：李素云
企業QQ：2851195446，2851195466
手機：18965423501
座機：0592-5165501
——控制定子磁鏈引入定子磁鏈觀測器，實現無速度傳感器方式;
——自動識別(ID)依靠的電機數學模型，對電機參數自動識別;
——算出實際值對應定子阻抗、互感、磁飽和因素、慣量等算出實際的轉矩、定子磁鏈、轉子速度進行實時控制;
——實現Band—Band控制按磁鏈和轉矩的Band-Band控制產生PWM信號，對逆變器開關狀態進行控制。
矩陣式交—交變頻具有快速的轉矩響應(<2ms)，很高的速度精度(±2%，無PG反饋)，高轉矩精度(<+3%);同時還具有較高的起動轉矩及高轉矩精度，尤其在低速時(包括0速度時)，可輸出150%～200%轉矩。
3 變頻器控制方式的合理選用
控制方式是決定變頻器使用性能的關鍵所在。目前市場上低壓通用變頻器品牌很多，包括歐、美、日及產的共約50多種。選用變頻器時不要認為檔次越高越好，而要按負載的特性，以滿足使用要求為準，以便做到量才使用、經濟實惠。表1中所列參數供選用時參考。 4 轉矩控制型變頻器的選型及相關問題
基于調速方便、節能、運行可靠的優點，變頻調速器已逐漸替代傳統的變極調速、電磁調速和調壓調速方式。在推出PWM磁通矢量控制的變頻器數年后，1998年末又出現采用DTC控制技術的變頻器。ABB公司的ACS600系列是代采用DTC技術的變頻器，它能夠用開環方式對轉速和轉矩進行準確控制，而且動態和靜態指標已優于PWM閉環控制指標。
Lot of 10 New SMC KQ2Y13-36S Pneumatic Male Run Tee 1/2" Tube 3/8" Thread
SMC NAFM3000-N03D Mist Separator 3/8" NPT
Lot of 10 New SMC KQ2T13-04S Pneumatic Tees 1/2" Tube 1/2" Thread
Lot of 10 New SMC KQ2L11-03S Pneumatic Fittings Elbow 3/8" Tube 3/8" Thread
SMC AW30-03 Pneumatic Filter Regulator RC 3/8 Thread
Lot of 8 New SMC KQ2VT06-02S Triple Universal Male Elbow 6mm Tube 1/4" R,Rc
SMC AW40-N04-2Z Pneumatic Filter Regulator 1/2" NPT
Lot of 5 New SMC AS3201F-N03-07S Flow Controls 1/4" Tube x 3/8" NPT Meter Out
Lot of 100 New SMC KQR03-07 Plug-In Reducer Pneumatic Fitting 5/32" to 1/4"
SMC NAFM4000-N04D Mist Seperator 1/2" NPT
New Bag of 10 SMC AS3201F-N03-07S Speed Flow Controls 3/8" NPT to 1/4" Tube
Lot of 10 SMC KQ2T07-35S Pneumatic Branch Tee Fitting 1/4" Tube x 1/4" NPT
New Bag of 10 KQ2T13-04AS SMC Pneumatic Tee Fittings 1/2" Tube to 1/2" R,Rc
New SMC VX230CGB Solenoid Valve 2-Port 1/4" NPT N.C.
New SMC ARP20-N01EH-3Z Percision Regulator 1.2-90PSI 1/8" NPT Ports
New SMC ARP20-N01EH-1Z Percision Regulator 0.75-30PSI 1/8" NPT Ports
New SMC SY3140-4LZ-01 Manifold 5-Port 2-Position Single Solenoid Internal Pilot
New Bag of 10 SMC KQ2LF03-34-X2 Pneumatic Fittings 5/32" Tubing x 1/8" NPTF
New SMC 10-SY3140R-5MZD-01 Manifold 5-Port 2-Position Single Solenoid
New SMC SY3440R-5L-01 Manifold 5-Port 3-Position Exhaust Center External Pilot
New Bag of 10 SMC KCH12-99 12mm Pneumatic Fittings w/ Self Seal for Tube Removal
Bank of 8 SMC SV2100-5FU 24VDC Solenoid Valves w/ SS5V2-16FD1-08 Manifold
Lot of 4 New SMC VQZ115-6L-CP Solenoid Valve 3-Port N.C. 12VDC Plug Connector
New SMC TIA01W-153 Nylon Tubing for Air/Water 20m 1/8" 3.18mm OD 2.18mm ID
New SMC SY3140R-5L-01 Manifold 5-Port 2-Position Single Solenoid External Pilot
SMC AMG250 Ambient Dryer 3/8" NPT, Water Seperator
SMC CXSM25-25 Guided Pneumatic Cylinder 25mm Bore 25mm Stroke 0.7MPa 101PSI
New SMC AR20-N01BE-1Z Pneumatic Regulator 0-30 PSI 1/8" NPT
SMC ARG20-N02G1-Z Pneumatic Regulator 0-150PSI 1/4" NPT
New SMC AR40-N04E-Z Pneumatic Regulator 0-150PSI 1/2" NPT
SMC NAW4000-N04D Pneumatic Filter 1/2" NPT
New SMC VX220EAB Solenoid Valve 24VDC 3/8" NPT
New SMC C96ST63-150 Pneumatic Cylinder, Double Acting, 63mm Bore, 150mm Stroke
SMC NVFS3300-5FZ Pneumatic Solenoid Valve 24VDC 14-145PSI *No Gasket / Screws*
New SMC MXQ6-30 Slide Table, 6mm Bore, 30mm Stroke, M5x0.8, 50-500mm/sec
New SMC NCGGN63-0800 High Speed Cylinder, Double Acting, 2-1/2" Bore, 8" Stroke
New SMC MIW20-20D Pneumatic 2 Finger Escapement, 20mm Bore, 20mm Stroke6DD1640-0AC0
6DD1642-0BC0
6DD1660-0AE0
6DD1681-0EK1
6ES5491-0LB11
6ES5928-3UA11
6ES7414-2XG03-0AB0
6GT2002-0AA00
C98043-A1682-L1
DS3810MMBB1A1A
IC693CHS391
IC693CHS392
PS02-3001V5.00
QLSAMBAN
R15E02A186
07SK90R1
10024/I/I CTD
10105/2/1
3A99158G01
3HAC14550-4/05A
3HAC14550-4/09A
505-4232A
505-4332
New SMC VCA35-5GB-7-04N Direct Operated 2-Port Solenoid Valve 7mm Orifice
New SMC VER4000 & VEP3121-2, 5-Port Electro-Pneumatic Proportional Valve
New SMC NVFA5320-02N-X1 5-Port Air Operated Valve 3-Position Closed Center
New SMC NCDA1D200-0300 Pneumatic Cylinder, Double Acting, 2" Bore, 3" Stroke
New SMC MRHQ25D-180S-M9PVL-M9PL Rotary Gripper w/Switch, 25mm-Bore 180-Degree
SMC MHQG2-32D-Y59A Pneumatic Parallel Gripper w/Switch, 32mm Bore, Double Acting
SMC MHQG2-40D Pneumatic Parallel Gripper, Double Acting, 40mm Bore, 28mm Stroke
New SMC MGPM100-50AZ Pneumatic Cylinder, Guided, 100mm Bore, 50mm Stroke
SMC VQ2100N-5C1 Solenoid Valve, VQ2000, 5-Port, 2-Position Single, 24VDC
SMC VQ2300-5C1 Solenoid Valve, VQ2000, 5-Port, 3-Position Closed Center, 24VDC
Hypro 100xKPa 0/160PSI 2.5" 400FD 1/4CBM
免責聲明：（1）以上所展示的信息由企業自行提供，內容的真實性、準確性和合法性由發布企業負責，環球塑化網對此不承擔任何保證責任。我們?cè)瓌t上建議您優先選擇“塑企通”會員合作! （2）同時我們鄭重提醒各位買/賣家，交易前請?jiān)敿?xì)核實對方身份，切勿隨意打款或發貨，謹防上當受騙。如發現虛假信息，請向環球塑化網舉報。
簡繁切換