廈門阿米控技術有限公司

abb 07SK90R1  直接轉矩控制以測量電機電流和直流電壓作為自適應電機模型的輸入。該模型每隔25μs產生一組的轉矩和磁通實際值，轉矩比較器和磁通比較器將轉矩和磁通的實際值與轉矩和磁通的給定值進行比較，以確定開關位置。由此可以看出它是通過對轉矩和磁通的測量，即刻調整逆變電路的開關狀態，進而調整電機的轉矩和磁通，以達到控制的目的。

廈門岳航計算機工程有限公司

聯系人：李素云

企業QQ：2851195446，2851195466

手機：18965423501

座機：0592-5165501

4.1選型原則

先要根據機械對轉速和轉矩(起動、連續及過載)的要求，確定機械要求的輸入功率(即電機的額定功率值)。有經驗公式

P=nT/9950(kW)

式中:P——機械要求的輸入功率(kW);

n——機械轉速(r/min);

T——機械的轉矩(N·m)。

然后，選擇電機的極數和額定功率。電機的極數決定了同步轉速，要求電機的同步轉速盡可能地覆蓋整個調速范圍，使連續負載容量高一些。為了充分利用設備潛能，避免浪費，可允許電機短時超出同步轉速，但必須小于電機允許的轉速。轉矩取設備在起動、連續運行、過載或轉速等狀態下的轉矩。，根據變頻器輸出功率和額定電流稍大于電機的功率和額定電流的原則來確定變頻器的參數與型號。

需要注意的是，變頻器的額定容量及參數是針對一定的海拔高度和環境溫度而標出的，一般指海拔1000m以下，溫度在40℃或25℃以下。若使用環境超出該規定，則在確定變頻器參數、型號時要考慮到環境造成的降容因素。

SMC VQ2100-5C1 Solenoid Valve, VQ2000 Series, 5-Port, 2-Position Single, 24VDC

New SMC V111M-3MOZ Pilot Assembly, SY100 Solenoid Valve, 120VAC (missing screws)

New SMC V111M-3MOZ Pilot Assembly, SY100 Solenoid Valve, 120VAC

SMC 4228287 MPa 100PSI 1/8" NPT 111.16 1.5"

SMC MPa PSI Pressure Gauge 0-.2 0-30

CB 0-150 PSI Pressure Gauge 42.5 MM 1/8 NPT

New SMC CC63-100S02-5D Air Hydro Unit, 63mm Bore, 100mm Stroke, 24V

New SMC CDRA1BS50-90C Pneumatic Rotary Actuator, 90 Degree Rotation, 50mm Bore

SMC NCRA1BS80-90C Pneumatic Rotary Actuator, 90 Degree Rotation, 80mm Bore

Lot of 3 SMC SY50M-2-2DA-N7 Manifold Block 1/4 Side Port

SMC VQ4250-5H Solenoid Valve SOL 4/5 - Port 0.15-1.0MPa

Noshok 6000PSI Gauge Dry 316 Stainless Steel Tube & Socket 1/2" NPT 6.75" OD

Swagelok SS-8C-EP-1 Poppet Check Valve 1/2" Swagelok Tube Fitting 1PSI

Swagelok SS-8BK-TW-1C Bellows Valve N.C. Spring Return NW16 & NW25 Flanges

New Bimba HS-09 Hydraulic Shock Absorber 16mm(.63") Usable Stroke 1/2"-20 Thread

Bank of 4 Parker B31FBB553C Solenoid Valves 115/120VAC 50/60Hz 1.6VA

Norgren T74E-4AA-P1N Shut-Off & Lockout Valve, 3-Port 2-Position, 1/2"PTF Thread

ABM Pressure Gauge, 0-60PSI, 1/4"NPT, 2.70" Dia. Dial

Marshall Town Pressure Gauge, 0-15PSI, 1/4"NPT, 2.62" Dia. Dial

Penguin Pressure Gauge, 0-4bar, 0-60PSI, 1/4"NPT, 2.43" Dia. Dial

Wika Pressure Gauge, 0-60PSI, 1/4"NPT, 2.44" Dia. Dial

Plast-o-matic Pressure Gauge, 0-60PSI, 1/4"NPT, 2.12" Dia. Dial

Wika Pressure Gauge, 0-100PSI, 1/4"NPT, 2.68" Dia. Dial

Ashcroft 8923 Pressure Gauge, Glycerin Filled, 0-60PSI, 1/4"NPT, 2.76" Dia. Dial

Wika Pressure Gauge, Glycerin Filled, 0-100PSI, 1/4"NPT, 2.68" Dia. Dial

Ashcroft Q-8962 Pressure Gauge, 0-60 PSI, 1/4" NPT

Norgren R07-200-RGKA Pneumatic Regulator w/0-160PSI Gauge, 300PSI-IN 100PSI-OUT6DD1640-0AC0

6DD1642-0BC0

6DD1660-0AE0

6DD1681-0EK1

6ES5491-0LB11

6ES5928-3UA11

6ES7414-2XG03-0AB0

6GT2002-0AA00

C98043-A1682-L1

DS3810MMBB1A1A

IC693CHS391

IC693CHS392

PS02-3001V5.00

QLSAMBAN

R15E02A186

07SK90R1

10024/I/I CTD

10105/2/1

3A99158G01

3HAC14550-4/05A

3HAC14550-4/09A

505-4232A

505-4332

505-4532

505-4632

Plast-o-matic Pressure Gauge, 0-60PSI, 1/4"NPT, 52mm Diameter Dial

Marsh 34693-3 Pressure Gauge, 4.8" Diameter Dial, 0-100PSI, 1/4"NPT

Plast-o-matic Pressure Gauge, 0-60PSI, 1/4"NPT

Weiss Instruments Pressure Gauge, 3.9" Diameter, 0-100PSI, 1/4"NPT

Ashcroft 238A460-02 Rev.E Pressure Gauge, Glycerin Filled, 0-60PSI, 1/4"NPT

New Gast 75R635-P101-H301X Twin Cylinder Compressor 115VAC 4A 4.05CFM 30PSI

Ashcroft 250-2456-BA Pressure Gauge, Silicone Filled, 0-60PSI, 1/4"NPT

Speedaire 4ZL81 Pneumatic Modular Air Line Lubricator, 1/2 In,

Ashcroft 250-2990A01 Pressure Gauge, 0-30PSI, 1/4"NPT